There are no vent plugs in the sealed battery cap. The battery is completely sealed except for two small ventilation holes on the side surfaces. Small amounts of generated gases are released through these vents. The specified battery has the following advantages over those commonly used.
- Does not require water refilling throughout the entire battery life.
- Availability of overcharge protection. If too much voltage is applied to the battery, it will not carry the same amount of current as a normal battery. In conventional batteries, excess voltage will result in overcharging, resulting in gas generation and corresponding fluid loss.
- Lower self-discharge compared to commonly used batteries. This property is especially important when storing the battery for long periods of time.
- High power output with smaller dimensions and weight.
Precautions when working with batteries
- The battery constantly releases hydrogen. When charging, more hydrogen is released. Hydrogen is highly explosive.
- Always disconnect the negative battery cable first and reconnect it last.
- Sulfuric acid is the basis of battery electrolyte. This acid is highly corrosive, corroding metals, damaging paint and fabric, and can cause serious injury if it comes into contact with eyes or skin. If electrolyte comes into contact with your skin, wash it off immediately with clean water.
- If electrolyte gets into your eyes, rinse them with water for at least 15 minutes and seek medical attention.
- If electrolyte is accidentally swallowed, immediately drink plenty of water or milk. Then drink magnesium, a raw egg or vegetable oil. Seek medical attention immediately.
- When working with or charging a battery, make sure the area is well ventilated.
- Never bring an open flame, a burning cigarette, or other objects that cause sparking close to the battery pack that is being charged or the engine is being started from the auxiliary battery pack.
- When checking and servicing the battery, always turn off the engine and all electrical consumers in the vehicle.
- Never interrupt the power supply circuit to the battery terminals. This can cause an arc to occur, which will ignite the hydrogen released from the battery.
- When working with batteries, wear safety glasses. When disconnecting battery cables or working near the battery, keep metal objects and tools away from the battery terminals. The resulting short circuit or spark may damage the battery or ignite the hydrogen gas near the battery.
- Never move the battery with the cell caps removed, as this can easily cause the electrolyte to spill out.
- Always use a battery carrier when lifting the battery or grasp the bottom edge of the battery with your hands.
- Cover the car body to prevent electrolyte splashes.
- Keep sharp objects away from the battery tray to avoid damaging the battery case and do not overtighten the battery fasteners.
(Information copied from the website: NissanBook.ru)
To prevent damage, please observe the warning symbols on the battery case.
The symbols have the following meanings:
1. Read the safety precautions in the operating instructions.
2. Corrosion hazard: Battery electrolyte is highly corrosive. For this reason, it is necessary to wear protective gloves and glasses when working with a battery. Do not turn the battery upside down, as electrolyte may leak from the ventilation holes.
3. The use of open flames, sparks and smoking near the battery are prohibited. If the battery is only disconnected from the cables but not removed, the battery terminals should be covered for safety.
4. Wear protective glasses.
5. Store electrolyte and battery out of reach of children.
6. Dispose of old batteries in designated places.
7. Do not dispose of old batteries in household waste.
8. Explosion hazard. When charging a battery, an explosive gas is generated.