Brake Specifications System type electronic 4-channel / 4-sensor ABS with electronic brake force distribution and Brake Assist (possible to order). Ventilated disc front, disc or drum rear,...
General information about the brake system Diagram of the hydraulic brake circuit for non-ABS models 1 - Front brake mechanism; 2 - Rear brake mechanism; 3 - Non-separable pressure limiter; 4 - GTZ Diagram of the...
Replacing the brake pads of disc brakes Warning! The brake pads must be replaced on both front/rear brakes at the same time. Remember that the dust generated during the operation of the brake mechanisms may...
Removal and installation of brake calipers Front wheel disc brake components 1 - Anchor bracket; 2 - Guide pin bolts (22÷31 Nm); 3 - Shoe holders; 4 - Protective covers for guide pins; 5 - Guide pins; 6 - Hollow...
Removal and installation of wheel cylinders Note. In the event of leakage, the wheel cylinders must be replaced without fail. Manufacturers do not recommend attempting to refurbish these brake assemblies. Wheel...
Removal and installation of the main brake cylinder GTZ Assembly Components 1 - Tank cover; 2 - Mesh filter; 3 - float; 4 - Tank body; 5 - Through bushings; 6 - Built-in two-way pressure regulator (dosing valve); 7 - Nut...
Replacing the dosing valve-regulator Note. On models 1993 and 1994 issue the metering valve-regulator is built into the GTZ assembly. 1. On models since 1995 without anti-lock brakes (ABS), there are two...
Bleeding the brake system Attention! Bleed the brake system while wearing goggles. If brake fluid accidentally gets into your eyes, rinse immediately with plenty of water and seek medical...
Parking brake adjustment Attention! Some of the models in question are equipped with an additional security system (SRS). Be sure to deactivate the SRS system before servicing components located...
Replacing the parking brake cable The layout of the parking brake cable drive is shown in the illustration. Laying diagram of the torsion drive of the parking brake 1 - Control lever; 2 - Bolt (8÷11 Nm);...
Foot brake pedal adjustment 1. Peel back carpet and floor panel insulation. With the foot brake pedal fully released, measure the distance from the pedal shoe rubber pad surface to the floor...