The location of components and assemblies in the car Location of components and assemblies in the engine compartment, top view 1. Oil filler cap; 2. Engine oil level gauge; 3. Battery; 4. Nutrient tank of the main brake...
Maintenance technical data Recommended lubricants and fluids - see subsection 1.12.7 . Refueling tanks (l) Engine oil 3,2 Cooling system: - vehicles with manual transmission 5,5 - cars with...
Oil and oil filter change (15000 km) Attention! If the maintenance procedure has not been followed for a long time, then the checks and adjustments described below should be carried out as necessary. Timely...
Checking idle speed and mixture quality (15,000 km) Carburetor engines (1.6 l) without catalytic converter 1. Check ignition timing (see subsection 7.7.7 ). 2. Make sure the spark plugs are in good condition and the spark...
Checking leaks and condition of hoses (15,000 km) 1. Inspect all detachable connections of the engine, check for traces of oil or coolant leaks from under the gaskets and seals. Particular attention should be paid to...
Checking and adjusting the clutch drive 1. Check the clutch pedal stroke - the pedal should move smoothly, without jamming, throughout the entire working stroke. 2. Also check that there is no slippage or...
Fuel filter replacement (30,000 km) Attention! When replacing the filter, observe fire safety regulations. 1. The fuel filter is mounted on the bulkhead of the engine compartment on the left side. Before...
Brake fluid change (30,000 km) 1. The procedure is similar to removing air from the hydraulic brakes (see subsection 11.2 ). Before changing the liquid, suck out the used liquid from the nutrient tank...
Suspension and steering check (30,000 km) 1. Put the car on the handbrake, raise the front of the car and place it on stands. 2. Inspect rubber ball joint boots and steering gear boots for cracks, tears, and...
Checking the covers of the axle shafts (30,000 km) 1. Raise the car and put it on stands. 2. Turn the steering wheel all the way and turn the wheel slowly. 3. Check the condition of the rubber boot of the outer CV joint,...
Exhaust system check (30000 km) 1. Check the condition of the exhaust system from the engine to the end section. Perform the check on a cold engine, at least 1 hour after the trip. To check, it is best...
Wheel alignment check (30,000 km) Definitions 1. The stability of the car when turning and the optimal position of the front wheels in space are determined by four basic angles, which are expressed in...
Wheel swap (30,000 km) Wheel swap diagram (radial tires) A. Without standard spare wheel B. With stock wheel It is carried out in order to evenly wear all tires. The wheels are rearranged...
Checking the rear drum brake pads (30,000 km) 1. Block the front wheels, raise the rear of the vehicle and place it on stands. Remove rear wheels. 2. To check the wear of the rear brake pads without removing the...
Checking the condition of seat belts (30,000 km) All vehicles are equipped with 3-point seat belts. The front and rear seat belts are equipped with an inertial reel, the middle rear seat is equipped with a static type...
Lubrication of door hinges and locks (30,000 km) 1. Lubricate the hinges on the hood, doors and trunk or cargo area with light-weight machine oil. 2. Also lubricate the tongues of the locks, latches, and latches with...
Checking the car on the road (30,000 km) Instruments and electrical equipment 1. Check the operation of all instrumentation and electrical equipment. 2. Make sure that the readings of the devices are correct,...
Air filter replacement (60,000 km) 1. Loosen the nut (or nuts) and air filter cover bolt (indicated by arrows). 2. Loosen the spring clips on the air filter cover. 3. Remove the air filter cover (in the...
Checking the ignition system (60,000 km) Attention! The voltage generated by the ignition system is much higher than the voltage from other vehicle systems. When performing work with the ignition on, special...
Replacing the crankcase ventilation filter (60,000 km) Carbureted engine 1. Unscrew the nut and screw of the air filter cover, disconnect the latches. 2. Remove the cover and turn over to access the crankcase ventilation...
Checking the hose and control vacuum booster (60,000 km) 1. Check up a condition of a vacuum hose on all length, reliability of connection of a hose. 2. If defects are found, replace the hose. 3. Refer to Check Valve Test...
Coolant change (60,000 km) Attention! The procedure is performed on a completely cold engine, in compliance with the safety measures for working with toxic liquids. 1. Carefully unscrew the...
Oil change in manual transmission (120,000 km) 1. It is advisable to change the oil immediately after a trip so that the engine and gearbox are warmed up to operating temperature. 2. Park the car on a level surface,...